Browse Categories
DIESELSITE FORD TRANSMISSION FILTRATION SYSTEMS

Hey, guys and or gals! 
Just wanted to drop you a quick note here.  I purchased your dieselsite transmission filter kit with pressure gauge for my 02 diesel excursion.  I had to share this with you.  I installed your kit when my truck had 30K on it.  I had already done the initial tranny service right when I bought it, and converted to using Mobil syn atf fluid.  After reading about your product I decided to purchase the filter kit.  Well after driving a 100,000 miles.  It was time to drop the pan and change the internal filter.   To my shocked surprise the pan was just as clean as if I just serviced it yesterday!   And when I pulled the oem tranny filter out, I could not believe it.  The filter was not even dirty.  Amazing even after 100K of driving.  And there was zero debris in my pan. And the transmission shifts just as g ood now with 131,xxx as it did when I bought it.   
Im just stunned, that that little spin on filter is doing that good of a job.  You guys should be selling these to Ford.  
I also, purchased the coolant filter kit from you as well.  That one I was always leery about. But I read on several diesel post board about a coolant filter. And figured ah, what the heck, better have one.  Seeing the rate of water pumps going out.  But the curious george in me, decided to cut a old filter open.  Man you guys were spot on.  I could not believe the junk that was in there.  That's crazy.  So, for sure as you showed in the picture and your information was accurate 100%. 
 A happy customer !
Jason

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

1994-2003 DIESELSITE 7.3L ADRHPOP

Bob,
I would like to thank you for putting such a fine product together as you did with the Adrenaline pump. I purchased my pump from you last year in June [2009]. It's still going strong. My Excursion feels like a champ everyday. Has been driven all over the US been to over 35 states with your pump! Just found out my pride and joy (Early 99 bought new) needs HPOP. I know what I have to do of course, buy another Adrenaline pump from you. By the way, I already put 90,000 miles on my Adrenaline Pump!
Thanks Again for your help,    
Raul B.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Bob,
I finally got on the dyno on Saturday and was very impressed by what I saw. My horsepower went up 25-85 horsepower across the board. The torque gain was even more impressive going up on avereage between 180ftlbs and 200ftlbs on all the programs I have, INCLUDING STOCK. The icp on the 120hp and 140hp programs was 3081 (icp duty cycle was 58.9) and 3057 (icp duty cycle was 57.03). Pulls made on the dyno this time were a lot smoother and the graph looks perfect. Now I just need the air to go with the fuel!
By the way, I picked up 40 miles on the front tank alone. That's my favorite thing about this pump. Thank you!

Chris- 1996 7.3L - Hybrid 530 Injectors - Stock Turbo - DP-Tuner - 388.3 HP / 1030 TQ
 - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

Bob,
Using the economy setting on chip that's been reburned by Tony Wildman, I have increased by mileage from a confirmed 12 MPG to 14! Keep in mind, prior to your new pump I was running the stock Superduty HPOP. When I was running the stock OBS HPOP, I was getting around 11 MPG, but I was still using standard OBS tunes on the chip. 11 to 14 is nearly a 22% gain in fuel economy!  BIG NUMBERS!
The extreme setting knocked .5 seconds off my 1/4 mile times too.  It would have been more if I didn't have a 20 MPH head wind that day at the track.

Brad - 1997 7.3L - Stage I Injectors - TW Tuning
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

Bob,
I just want to say thanks for the GREAT customer service, the instructions included with the pump made install a breeze. From start to finish (including an oil change) was about 2.5 hours. As far as the way the Adrenaline made my truck run; all I can say is WOW! My truck has 250,000 miles on it, running the stock injectors (and I mean stock injectors with all 250,000 miles on them) with Bill's tunes from PHP, and it runs like it never has before! The increase in power and response is almost hard to believe. Oil pressure is up instantaneously, and it stays up all the way to red line in every gear. I never thought I would see performance and drivability improvements like this with just the addition of an oil pump. Thanks again for a GREAT product and absolutely world class customer service.
-Mark H.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

Mr. Riley,
I just want to say that your Adrenaline HPOP is a fantastic product. I am very impressed with the finish of the pump and performance.
Let me tell you a little about the truck. It is a STOCK 95' F250 with 425,000 on the engine & 626,000 on the truck. Very well taken care of.
The truck has numerous new and reman parts. On its way is a turbo rebuild kit with a 1.0 housing that I will use with your wicked wheel. I have a serious up pipe leak that is hampering my turbo boost.
Despite that, I installed the pump in only 4 hours with ease. The truck started easily and I have now driven about 50 miles. The pump smoothed the idle dramatically and the engine is far quieter and smoother.
Before, if I floored it, the truck would actually slow down! Now it just keeps pulling and once the turbo is fixed I'm sure it will only get better.
I drove up a 6% highway grade that before I could barely accelerate in 5th from 60 to 70mph. EGT would bump 1000 and boost 9-10psi.
Now I effortlessly passed 70mph in 5th. EGT about 900 and boost a mere 6psi! I cant wait for the turbo to see what it can really do! Maybe a chip or bigger injectors someday.
THANKS!
Garrett H.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Thank you very much!!! The Adrenaline pump is awesome! 2mpg increase on a STOCK 450,000 mile truck! It runs so much smoother and crisper and pulls all the way to redline now!
Thanks,
Terry

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

I've made two trips to the Oregon coast and one trip to the high mountains to go camping so far. The Adrenaline HPOP has really made a noticeable difference. My mileage has increased slightly (.3 mpg) pulling the camp trailer. The power, however, is substantially improved. This last trip to the mountains has the longest, hardest pull of anywhere we go (7% grade). I used to have to floor it at the base and would be topping the summit around 50-55 mph with my foot still planted firmly on the floor. That's if no one got in my way to slow me down. If anyone did slow me down,  I would top the summit at whatever speed I got slowed down to. I could never pick up speed once I got slowed down. This last trip with the Adrenaline installed I had throttle to spare and crested the summit at 65 mph. I could actually pick up speed pulling my 23 foot camp trailer going up a 7% grade to pass slower traffic when we hit the passing lanes. The EGT on the Tony Wildman tow setting never got above 1250 degrees and it pulled it on 8 pounds less boost than it used to. My normal driving has shown an increase of .5 mpg. I would highly recommend this to anyone looking for an upgrade to their factory HPOP. It's been a great product so far and hasn't, to date, given even a hint of a problem, and I anticipate it staying this way. Thanks for another great product Bob.
Lynn C.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Just wanted to send an update on our Adrenaline HPOP.  We are thrilled with the performance of the unit.  We took our first camping trip of the season with our fully loaded trailer and the pump performed flawlessly.  We didn't think the fuel mileage would improve but it did. Towing, it picked up 1.5 to 2 MPG.  While not towing we got 19 MPG.  Our best before was 17 MPG.  Seems like we picked up A LOT of power too.  Our "Wildman" stock setting is all we need.  On the other settings we have so much power that our Con-O clutch starts to slip. Thanks!
Kay & Lauri M.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

I was having SES light issues and the P1211 code with my ALL STOCK truck when towing uphills and at wide open throttle (WOT) when empty or towing for more than a few seconds. After finding out about the Adrenaline pump (through the FTE forum), I contacted Bob and he indicated that this pump would definitely help - man was he RIGHT! I had to wait a couple of weeks for the pump to be manufactured and sent off, but it was worth it.
The install wasn't too bad, about 4 hours, if you take out lunch and a run to the auto store to get RTV for the cover plate (not mentioned in the instructions that I needed RTV). I called Bob twice, first time to ask about getting the drive bolt off, as I tried to loosen it the whole engine turned. He recommended I use a breaker bar and hit with a hammer to simulate an impact wrench. It worked. The second was to ask about tricks to get the oil lines back on, he told me to suck it up and keep trying (not quite those words), it worked, I got them back on. Tightened it all back up, no oil leaks, but a small fuel leak out of the upper line - I did not have bushing or o-rings or whatever I needed there. So, for not even a shade tree mechanic, not a terribly difficult process. Oh, I did seem to have a little bit of air in there, so I ran it for a while on the freeway, then "burped" the air out by cracking the ICP when done. Air out, starts beautifully. I think engine noise when accelerating is down a bit too.
HUGE Results -my ICP pressure flattened out over 2800psi - it did not drop once it flattened. That is a gain of almost 1,000psi!  I had incredible power continuing up to speed. I used to get a SES and 1211 after WOT for about 5 seconds, then the light. I also noticed (prior to this) that once the truck got going, it seemed to hit a wall and stay there. Now with the Adrenaline, it is the energizer bunny - just keeps going. I also can't wait to get a trailer behind it. I used to dread all the hills, now I can't wait to run up them. THANKS BOB and SHERYL!
Jim B.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
This is my early 99 f-250 psd it has 250,000 miles and all original and I have owned it since new. I have installed a billet converter, DIY  intake, crankcase vent system, 4"turbo-back exhaust, an adrenaline  HPOP, edge evo 2 programmer. the best addition to to truck to date would have to be the adrenaline. That thing is awesome! It pulls like hell now!!! I feel like I am 16 again and can't wait to wake up to drive! Future mods include a CPR fuel system a d66 turbo and stage 2 injectors. Man...I still can't  believe the HPOP...with it turned to stock it feels like the tow program! Waiting on my BRV . It throws a boost code every time i step on it now! Great job Bob and Sheryl Thanks for all the help!
Mike B.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
As you know, I built this truck to tow with. Our latest journey has taken us from Idaho to Colorado. Lots of long uphills and altitude changes. My truck has NEVER pulled as hard as it does now! This pump has given me a whole different truck. The power comes on sooner and the torque curve is so broad and flat it's amazing.  A short story...we were leaving Ogden, Utah up Echo Canyon to Evanston, Wyoming . It's basically 70 miles of up hill, twisting canyon road. Speed limit 75 with 55 mph corners. Remember I just scaled at 26,160 lbs. so this is a heavy load. Anyway, I find myself having to SLOW DOWN for the corners! I was grinning from ear to ear. Bob and Sheryl, you have hit a home run with this pump. The 7.3 is alive and well because of people like you.
Barney F.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Here is the first Dieselsite FedEx truck. I had an hpop go out and was looking for a replacement. I used Bobs adrenaline for the 7.3. This thing used to have no power. Start ups were horrible. It couldn't even get out of its own way. Once the pump was installed ,those problems were history. This thing starts great and has more power than it ever has. It's quieter, and just runs great. 356,000 miles on stock injectors as well. His pump brought my FedEx truck back to life. Highly recommend it. Thanks, Bob and Sheryl.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

COLD RUSH

Bob, Cold Rush is an outstanding product with simple, easy to follow installation instructions. Being able to enjoy cool outside temperatures with the vents in any setting without the use of the A/C is what I've always wanted. Colder air in the summer with the flip of a switch is like having a whole other setting.This product pays for itself with the gas savings alone!. AAAA+++
Thanks.
Demoe


- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

TRU COOL TRANSMISSION COOLER

Bob, I purchased a Tru-Cool Trans cooler a couple of weeks ago. Went on easily.  It's nice to finally have something advertised and work as well as such. The trans temp with a large, approx. 14800# of tractors and trailer + truck, load, the temp was 40 degrees cooler than normal.
Thanks again.
Tim H.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

1994-1997 FORD PSD FUEL SYSTEM

Got my fuel system from Bob on Thursday afternoon about 5PM from the brown truck,I immediately opened it up and started unpacking it. Went to work on it Friday morning for about 3 hours, then again this afternoon for a bit. Finished it up, had dinner then went for a ride to test it out.OMG. I could not believe the difference this system made. I was not really thinking that I would be able to feel the difference by installing it, but man I was WRONG! Nice power gain on the low end, but where it really seems to shine is the high end. Was on the highway, floored it and it just kept pulling and pulling till I let off. The kit came complete with everything needed for the install, and when I say everything, I mean everything right down to the last wire tie. The full color instruction manual binder that comes with it also is top notch.The way that it is explained how to do install it is very simple. Before ordering this system, I was on the fence on whether to buy this kit or find and locate all the parts needed and do it myself. Man, am I glad I went with DIESELSITE. I want to thank Bob and Sheryl for all the great work that they put into this system. It's definitely a winner in my book. Now if I can only get my pulse pump here and installed before dyno day. (Bob you listening?) Keep up the great work guys.  

Posted by diesel 97
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
WOW, what a difference from go. Idle is so smooth now. Starts so fast now it seems if you look at the keys it will turn over. On take off, the truck will spool as normal, 30 lbs but now when the truck shifts through the gears, my boost only dips down 2-5 lbs, staying up at 25-27 lbs until I get out of the pedal.

Posted by BardorBrad
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Just received my new CPR fuel system and installed it over the weekend. Definitely a nice upgrade! The truck runs a lot smoother and is noticeably quieter. The quality of all the parts and pieces are outstanding. I've been building street rods for about 17 years, and I'd have to say that it is very rare to get a kit that is this well thought out and put together. The install instructions are incredible.
Thanks Bob,
Andy


- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

MAX AC

Thanks for the info.  It's all hooked up and I can just about frost the windows.
Tim J.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
My A/C works like it should now. Thanks so much!
Frank B.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Hey Bob, another great product. I have delayed a long time in ordering the AC control valve, sure wish I had done it sooner. Thanks for the usual quick order processing. You all might think this is funny, I am still doing mods on “Old Reliable” with 714,000 miles. I sure wish I could order another 02. The AC control valve has been one of those items on the wish list for a long time.  I always like to share my opinions about products. The products that work well, and are good improvements, deserve recognition. The marketplace has plenty of “snake oil” with false promises. I have been very pleased with every purchase at the Dieselsite.
Thanks again,
John A.


- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

COOLANT FILTRATION SYSTEMS

Dear Bob,
I purchased one of your coolant filters for my 6.0L PSD - 2003 Ford Excursion, and am now a true believer in your system. I installed your set-up at 51,090 miles and just changed it at 57,150 (6,060 on filter).  Keep in mind that the dealer drained and replaced my lower radiator hose at 30,000 miles, and I flushed my system 5 times with distilled water before installing...and look what your coolant filter system did to filter the sand, grit and sludge from my cooling/heating system!
Jeff C.

- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -